Airworthiness Directives; McDonnell Douglas Model DC-8 Series Airplanes

[Federal Register Volume 66, Number 81 (Thursday, April 26, 2001)]
[Rules and Regulations]
[Pages 20920-20921]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 01-9938]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. 99-NM-276-AD; Amendment 39-12197; AD 2001-08-20]
RIN 2120-AA64


Airworthiness Directives; McDonnell Douglas Model DC-8 Series 
Airplanes

AGENCY: Federal Aviation Administration, DOT.

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: This amendment adopts a new airworthiness directive (AD), 
applicable to certain McDonnell Douglas Model DC-8 series airplanes, 
that requires replacing the toilet flushing circuit breakers of the 
lavatory with new circuit breakers, and marking applicable nameplates. 
This action is necessary to prevent overheating of the flush pump 
motor, which could result in damage to the flush pump motor cover, and 
consequent smoke in the lavatory area. This action is intended to 
address the identified unsafe condition.

DATES: Effective May 31, 2001.
    The incorporation by reference of certain publications listed in 
the regulations is approved by the Director of the Federal Register as 
of May 31, 2001.

ADDRESSES: The service information referenced in this AD may be 
obtained from Boeing Commercial Aircraft Group, Long Beach Division, 
3855 Lakewood Boulevard, Long Beach, California 90846, Attention: Data 
and Service Management, Dept. C1-L5A (D800-0024). This information may 
be examined at the Federal Aviation Administration (FAA), Transport 
Airplane Directorate, Rules Docket, 1601 Lind Avenue, SW., Renton, 
Washington; or at the FAA, Los Angeles Aircraft Certification Office, 
3960 Paramount Boulevard, Lakewood, California; or at the Office of the 
Federal Register, 800 North Capitol Street, NW., suite 700, Washington, 
DC.

FOR FURTHER INFORMATION CONTACT: Elvin Wheeler, Aerospace Engineer, 
Systems and Equipment Branch, ANM-130L, FAA, Los Angeles Aircraft 
Certification Office, 3960 Paramount Boulevard, Lakewood, California 
90712-4137; telephone (562) 627-5344; fax (562) 627-5210.

SUPPLEMENTARY INFORMATION: A proposal to amend part 39 of the Federal 
Aviation Regulations (14 CFR part 39) to include an airworthiness 
directive (AD) that is applicable to certain McDonnell Douglas Model 
DC-8 series airplanes was published in the Federal Register on 
September 1, 2000 (65 FR 53206). That action proposed to require 
replacing the toilet flushing circuit breakers of the lavatory with new 
circuit breakers, and marking applicable nameplates.

Comment Received

    Interested persons have been afforded an opportunity to participate 
in the making of this amendment. Due consideration has been given to 
the comment received.
    One commenter requests that the applicability of the proposed be 
revised to exclude airplanes in a freighter configuration on which the 
toilet flushing systems and associated equipment have been removed.
    The FAA agrees. We find that McDonnell Douglas Model DC-8 series 
airplanes that have been converted from a passenger to a cargo-carrying 
(``freighter'') configuration, without toilet flushing systems and 
associated equipment installed, are not subject to requirements of this 
AD. Therefore, we have removed these airplanes from the applicability 
of the final rule.

Conclusion

    After careful review of the available data, including the comment 
noted above, the FAA has determined that air safety and the public 
interest require the adoption of the rule with the change previously 
described. The FAA has determined that this change will neither 
increase the economic burden on any operator nor increase the scope of 
the AD.

Cost Impact

    There are approximately 232 Model DC-8 series airplanes of the 
affected design in the worldwide fleet. The FAA estimates that 199 
airplanes of U.S. registry will be affected by this AD, that it will 
take approximately 1 or 2 work hours per airplane, depending on the 
configuration of the airplane, to accomplish the required actions, and 
that the average labor rate is $60 per work hour. Required parts will 
cost approximately $348 per airplane. Based on these figures, the cost 
impact of the AD on U.S. operators is estimated to be $408, or $468 per 
airplane, depending on the configuration of the airplane.
    The cost impact figure discussed above is based on assumptions that 
no operator has yet accomplished any of the requirements of this AD 
action, and that no operator would accomplish those actions in the 
future if this AD were not adopted. The cost impact figures discussed 
in AD rulemaking actions represent only the time necessary to perform 
the specific actions actually required by the AD. These figures 
typically do not include incidental costs, such as the time required to 
gain access and close up, planning time, or time necessitated by other 
administrative actions.

Regulatory Impact

    The regulations adopted herein will not have a substantial direct 
effect on the States, on the relationship between the national 
Government and the States, or on the distribution of power and 
responsibilities among the various levels of government. Therefore, it 
is determined that this final rule does not have federalism 
implications under Executive Order 13132.
    For the reasons discussed above, I certify that this action (1) is 
not a ``significant regulatory action'' under Executive Order 12866; 
(2) is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and (3) will not have a 
significant economic impact, positive or negative, on a substantial 
number of small entities under the criteria of the Regulatory

[[Page 20921]]

Flexibility Act. A final evaluation has been prepared for this action 
and it is contained in the Rules Docket. A copy of it may be obtained 
from the Rules Docket at the location provided under the caption 
ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

    Accordingly, pursuant to the authority delegated to me by the 
Administrator, the Federal Aviation Administration amends part 39 of 
the Federal Aviation Regulations (14 CFR part 39) as follows:

PART 39--AIRWORTHINESS DIRECTIVES

    1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec. 39.13  [Amended]

    2. Section 39.13 is amended by adding the following new 
airworthiness directive:

2001-08-20  McDonnell Douglas: Amendment 39-12197. Docket 99-NM-276-
AD.

    Applicability: Model DC-8 series airplanes, as listed in 
McDonnell Douglas Alert Service Bulletin DC8-24A068, Revision 01, 
dated November 1, 1999; certificated in any category; except those 
airplanes that have been converted from a passenger to a cargo-
carrying (``freighter'') configuration, without toilet flushing 
systems and associated equipment installed.

    Note 1: This AD applies to each airplane identified in the 
preceding applicability provision, regardless of whether it has been 
modified, altered, or repaired in the area subject to the 
requirements of this AD. For airplanes that have been modified, 
altered, or repaired so that the performance of the requirements of 
this AD is affected, the owner/operator must request approval for an 
alternative method of compliance in accordance with paragraph (c) of 
this AD. The request should include an assessment of the effect of 
the modification, alteration, or repair on the unsafe condition 
addressed by this AD; and, if the unsafe condition has not been 
eliminated, the request should include specific proposed actions to 
address it.

    Compliance: Required as indicated, unless accomplished 
previously.
    To prevent overheating of the flush pump motor, which could 
result in damage to the flush pump motor cover, and consequent smoke 
in the lavatory area, accomplish the following:

Replacing Circuit Breakers and Marking of Nameplate

    (a) Within 2 years after the effective date of this AD, replace 
the toilet flushing circuit breakers of the lavatory with new 
circuit breakers, and mark applicable nameplates, in accordance with 
McDonnell Douglas Alert Service Bulletin DC8-24A068, Revision 01, 
dated November 1, 1999.

    Note 2: Replacements and markings accomplished prior to the 
effective date of this AD in accordance with McDonnell Douglas DC-8 
Service Bulletin 24-68, dated February 14, 1984; are considered 
acceptable for compliance with the requirements of paragraph (a) of 
this AD.

Spares

    (b) As of the effective date of this AD, no person shall install 
a 2 amp toilet flushing circuit breaker, part number MP1503-DC8, on 
any airplane.

Alternative Methods of Compliance

    (c) An alternative method of compliance or adjustment of the 
compliance time that provides an acceptable level of safety may be 
used if approved by the Manager, Los Angeles Aircraft Certification 
Office (ACO), FAA. Operators shall submit their requests through an 
appropriate FAA Principal Maintenance Inspector, who may add 
comments and then send it to the Manager, Los Angeles ACO.

    Note 3: Information concerning the existence of approved 
alternative methods of compliance with this AD, if any, may be 
obtained from the Los Angeles ACO.

Special Flight Permits

    (d) Special flight permits may be issued in accordance with 
sections 21.197 and 21.199 of the Federal Aviation Regulations (14 
CFR 21.197 and 21.199) to operate the airplane to a location where 
the requirements of this AD can be accomplished.

Incorporation by Reference

    (e) The actions shall be done in accordance with McDonnell 
Douglas Alert Service Bulletin DC8-24A068, Revision 01, dated 
November 1, 1999. This incorporation by reference was approved by 
the Director of the Federal Register in accordance with 5 U.S.C. 
552(a) and 1 CFR part 51. Copies may be obtained from Boeing 
Commercial Aircraft Group, Long Beach Division, 3855 Lakewood 
Boulevard, Long Beach, California 90846, Attention: Data and Service 
Management, Dept. C1-L5A (D800-0024). Copies may be inspected at the 
FAA, Transport Airplane Directorate, 1601 Lind Avenue, SW., Renton, 
Washington; or at the FAA, Los Angeles Aircraft Certification 
Office, 3960 Paramount Boulevard, Lakewood, California; or at the 
Office of the Federal Register, 800 North Capitol Street, NW., suite 
700, Washington, DC.

Effective Date

    (f) This amendment becomes effective on May 31, 2001.

    Issued in Renton, Washington, on April 17, 2001.
Donald L. Riggin,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 01-9938 Filed 4-25-01; 8:45 am]
BILLING CODE 4910-13-P

The complete text was extracted from the official GovInfo HTML edition for this publication. Acquired 2026-10-09T04:30:12.866658+00:00. Text extraction preserves the recorded source wording; it does not determine current requirements.

Open the captured official edition

Source SHA-256

e153914206112e49e3841adcb5865f9e6947231324c70ff91232a60efc6811b9

Text SHA-256

9bbbfb95415c44404c60c44737db25afac2dff0f191af672ebc423d4ba06a739