Airworthiness Directives; Gulfstream Model G-IV, GIV-X, GV, and GV-SP Series Airplanes

[Federal Register Volume 70, Number 156 (Monday, August 15, 2005)]
[Rules and Regulations]
[Pages 47722-47725]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 05-16003]


-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2005-22074; Directorate Identifier 2005-NM-152-AD; 
Amendment 39-14220; AD 2005-16-14]
RIN 2120-AA64


Airworthiness Directives; Gulfstream Model G-IV, GIV-X, GV, and 
GV-SP Series Airplanes

AGENCY: Federal Aviation Administration (FAA), Department of 
Transportation (DOT).

ACTION: Final rule; request for comments.

-----------------------------------------------------------------------

SUMMARY: The FAA is adopting a new airworthiness directive (AD) for all 
Gulfstream Model G-IV and GV series airplanes, and certain GIV-X and 
GV-SP series airplanes. This AD requires a one-time inspection to 
determine if a certain floor heater pad system is installed, and 
deactivation of the subject floor heater pad system if it is installed. 
This AD results from an incident of short-circuiting of the floor 
heater pads, in which no circuit breakers tripped in response to the 
short-circuiting. We are issuing this AD to prevent short-circuiting of 
the floor heater pad system, which could result in a fire in the 
airplane cabin.

DATES: Effective Date: August 30, 2005.
    The Director of the Federal Register approved the incorporation by 
reference of certain publications listed in the AD as of August 30, 
2005.
    We must receive comments on this AD by October 14, 2005.

ADDRESSES: Use one of the following addresses to submit comments on 
this AD.
    <bullet> DOT Docket Web site: Go to http://dms.dot.gov and follow 
the instructions for sending your comments electronically.
    <bullet> Government-wide rulemaking Web site: Go to http://www.regulations.gov and follow the instructions for sending your 
comments electronically.
    <bullet> Mail: Docket Management Facility; U.S. Department of 
Transportation, 400 Seventh Street SW., Nassif Building, Room PL-401, 
Washington, DC 20590.
    <bullet> Fax: (202) 493-2251.
    <bullet> Hand Delivery: Room PL-401 on the plaza level of the 
Nassif Building, 400 Seventh Street SW., Washington, DC, between 9 a.m. 
and 5 p.m., Monday through Friday, except Federal holidays.
    Contact Gulfstream Aerospace Corporation, Technical Publications 
Dept., P.O. Box 2206, Savannah, Georgia 31402-2206, for service 
information identified in this AD.

FOR FURTHER INFORMATION CONTACT: Robert Chupka, Aerospace Engineer, 
Systems and Equipment Branch, ACE-119A, FAA, Atlanta Aircraft 
Certification Office, One Crown Center, 1895 Phoenix Boulevard, suite 
450, Atlanta, Georgia 30349; telephone (770) 703-6070; fax (770) 703-
6097.

SUPPLEMENTARY INFORMATION:

Discussion

    We have received a report of an incident in which an Adel Wiggins 
floor heater pad system short-circuited on a Gulfstream GV-SP series 
airplane. The short-circuit was discovered after an odor of burning was 
detected emanating from the floor of the cabin. The short-circuit 
resulted in localized damage to the floorboard and carpet. No circuit 
breakers tripped as a result of the short-circuiting. This condition, 
if not corrected, could result in a fire in the airplane cabin.
    The subject Adel Wiggins floor heater pad system may also be 
installed on all Gulfstream Model G-IV and G-V series airplanes and 
certain Gulfstream Model GIV-X series airplanes. Therefore, those 
models may be subject to the unsafe condition revealed on certain Model 
GV-SP series airplanes.

Relevant Service Information

    We have reviewed the service information specified in the table 
below.

                 Relevant Gulfstream Service Information
------------------------------------------------------------------------
   For Gulfstream model--        Document title             Date
------------------------------------------------------------------------
G-IV........................  Gulfstream G-IV       June 13, 2005.
                               Alert Customer
                               Bulletin 33.
GV..........................  Gulfstream GV Alert   June 13, 2005.
                               Customer Bulletin
                               22.
G-IV (G300).................  Gulfstream G300       June 13, 2005.
                               Alert Customer
                               Bulletin 33.
GIV-X (G350)................  Gulfstream G350       June 13, 2005.
                               Alert Customer
                               Bulletin 2.
G-IV (G400).................  Gulfstream G400       June 13, 2005.
                               Alert Customer
                               Bulletin 33.
GIV-X (G450)................  Gulfstream G450       June 13, 2005.
                               Alert Customer
                               Bulletin 2.
GV-SP (G500)................  Gulfstream G500       June 13, 2005.
                               Alert Customer
                               Bulletin 3.

[[Page 47723]]

 
GV-SP (G550)................  Gulfstream G550       June 13, 2005.
                               Alert Customer
                               Bulletin 3.
------------------------------------------------------------------------

    The customer bulletins specified in the table above describe 
procedures for deactivating the Adel Wiggins floor heater pad system by 
capping and stowing all associated electrical wiring at each circuit 
breaker for the floor heater pads, opening and collaring each 
associated circuit breaker, and labeling each collared circuit breaker 
inoperative. Accomplishing the actions specified in the service 
information is intended to adequately address the unsafe condition.
    Each customer bulletin specified in the table above refers to 
Gulfstream Drawing 1159SB50018 as an additional source of service 
information for deactivating the Adel Wiggins floor heater pad system. 
This drawing is included as an attachment to each customer bulletin.

FAA's Determination and Requirements of This AD

    The unsafe condition described previously is likely to exist or 
develop on other airplanes of the same type design. Therefore, we are 
issuing this AD to prevent short-circuiting of the floor heater pad 
system, which could result in a fire in the airplane cabin. This AD 
requires inspecting the airplane to determine if an Adel Wiggins floor 
heater pad system is installed and, if one is installed, accomplishing 
the actions specified in the service information described previously, 
except as discussed under ``Differences Between the AD and Service 
Information.''
    We are allowing a special flight permit to be issued to operate the 
airplane to a location where the requirements of this AD can be 
accomplished, provided that circuit breakers for the floor heater pad 
system are pulled and collared.

Differences Between the AD and Service Information

    A note under paragraph 1.A., Effectivity, of Gulfstream G-IV Alert 
Customer Bulletin 33, Gulfstream GV Alert Customer Bulletin 22, 
Gulfstream G300 Alert Customer Bulletin 33, and Gulfstream G400 Alert 
Customer Bulletin 33, specifies contacting Gulfstream for assistance if 
an airplane with the Adel Wiggins floor heater pad system installed is 
not listed in the effectivity block of the referenced Gulfstream repair 
drawing. For any airplane that is found to have an Adel Wiggins floor 
heater pad system installed but that is not listed in the effectivity 
block of the referenced Gulfstream repair drawing, paragraph (h) of 
this AD requires deactivating the system in accordance with a method 
approved by the FAA.
    Also, although the Accomplishment Instructions of the referenced 
customer bulletins describe procedures for reporting compliance with 
the customer bulletin to Gulfstream, this AD does not require that 
action.
    These differences have been coordinated with the manufacturer.

FAA's Determination of the Effective Date

    Since an unsafe condition exists that requires the immediate 
adoption of this AD, we have found that notice and opportunity for 
public comment before issuing this AD are impracticable, and that good 
cause exists to make this AD effective in less than 30 days.

Comments Invited

    This AD is a final rule that involves requirements that affect 
flight safety and was not preceded by notice and an opportunity for 
public comment; however, we invite you to submit any relevant written 
data, views, or arguments regarding this AD. Send your comments to an 
address listed in the ADDRESSES section. Include ``Docket No. FAA-2005-
22074; Directorate Identifier 2005-NM-152-AD'' at the beginning of your 
comments. We specifically invite comments on the overall regulatory, 
economic, environmental, and energy aspects of the AD that might 
suggest a need to modify it.
    We will post all comments we receive, without change, to http://dms.dot.gov, including any personal information you provide. We will 
also post a report summarizing each substantive verbal contact with FAA 
personnel concerning this AD. Using the search function of that web 
site, anyone can find and read the comments in any of our dockets, 
including the name of the individual who sent the comment (or signed 
the comment on behalf of an association, business, labor union, etc.). 
You may review the DOT's complete Privacy Act Statement in the Federal 
Register published on April 11, 2000 (65 FR 19477-78), or you may visit 
http://dms.dot.gov.

Examining the Dockets

    You may examine the AD docket on the Internet at http://dms.dot.gov, or in person at the Docket Management Facility office 
between 9 a.m. and 5 p.m., Monday through Friday, except Federal 
holidays. The Docket Management Facility office (telephone (800) 647-
5227) is located on the plaza level of the Nassif Building at the DOT 
street address stated in the ADDRESSES section. Comments will be 
available in the AD docket shortly after the Docket Management System 
receives them.

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, Section 106, describes the 
authority of the FAA Administrator. Subtitle VII, Aviation Programs, 
describes in more detail the scope of the Agency's authority.
    We are issuing this rulemaking under the authority described in 
Subtitle VII, Part A, Subpart III, Section 44701, ``General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    We have determined that this AD will not have federalism 
implications under Executive Order 13132. This AD will not have a 
substantial direct effect on the States, on the relationship between 
the National Government and the States, or on the distribution of power 
and responsibilities among the various levels of government.
    For the reasons discussed above, I certify that the regulation:
    1. Is not a ``significant regulatory action'' under Executive Order 
12866;
    2. Is not a ``significant rule'' under the DOT Regulatory Policies 
and Procedures (44 FR 11034, February 26, 1979); and
    3. Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory

[[Page 47724]]

Flexibility Act. We prepared a regulatory evaluation of the estimated 
costs to comply with this AD and placed it in the AD docket. See the 
ADDRESSES section for a location to examine the regulatory evaluation.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Incorporation by 
reference, Safety.

Adoption of the Amendment

0
Accordingly, under the authority delegated to me by the Administrator, 
the FAA amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The Federal Aviation Administration (FAA) amends Sec.  39.13 by 
adding the following new airworthiness directive (AD):

2005-16-14 Gulfstream Aerospace Corporation: Amendment 39-14220. 
Docket No. FAA-2005-22074; Directorate Identifier 2005-NM-152-AD.

Effective Date

    (a) This AD becomes effective August 30, 2005.

Affected ADs

    (b) None.

Applicability

    (c) This AD applies to the airplanes identified in Table 1 of 
this AD, certificated in any category.

                         Table 1.--Applicability
------------------------------------------------------------------------
       Gulfstream model/series                    Serial Nos.
------------------------------------------------------------------------
G-IV................................  All.
GIV-X...............................  4001 through 4023 inclusive.
GV..................................  All.
GV-SP...............................  5001 through 5075 inclusive.
------------------------------------------------------------------------

Unsafe Condition

    (d) This AD results from an incident of short-circuiting of the 
floor heater pads, in which no circuit breakers tripped in response 
to the short-circuiting. The FAA is issuing this AD to prevent 
short-circuiting of the floor heater pad system, which could result 
in a fire in the airplane cabin.

Compliance

    (e) You are responsible for having the actions required by this 
AD performed within the compliance times specified, unless the 
actions have already been done.

Inspection To Determine If Subject System Installed

    (f) Within 25 flight hours or 30 days after the effective date 
of this AD, whichever is first: Perform an inspection to determine 
if an Adel Wiggins floor heater pad system is installed. A review of 
airplane maintenance records is acceptable in lieu of this 
inspection if the presence of Adel Wiggins floor heater pads can be 
conclusively determined from that review.

Deactivation of Adel Wiggins Floor Heater Pad System

    (g) If an Adel Wiggins floor heater pad system is found during 
the inspection required by paragraph (f) of this AD: Within 25 
flight hours or 30 days after the effective date of this AD, 
whichever is first, deactivate the Adel Wiggins floor heater pad 
system in accordance with the Accomplishment Instructions of the 
applicable customer bulletin identified in Table 2 of this AD, 
except as provided by paragraph (h) of this AD. Although the 
customer bulletins referenced in Table 2 of this AD specify to 
report compliance to the manufacturer, this AD does not require that 
action.

                      Table 2.--Service Information
------------------------------------------------------------------------
                               Customer bulletin,
      Gulfstream model        including Gulfstream          Date
                               drawing 1159SB50018
------------------------------------------------------------------------
G-IV........................  Gulfstream G-IV       June 13, 2005.
                               Alert Customer
                               Bulletin 33.
GV..........................  Gulfstream GV Alert   June 13, 2005.
                               Customer Bulletin
                               22.
G-IV (G300).................  Gulfstream G300       June 13, 2005.
                               Alert Customer
                               Bulletin 33.
GIV-X (G350)................  Gulfstream G350       June 13, 2005.
                               Alert Customer
                               Bulletin 2.
G-IV (G400).................  Gulfstream G400       June 13, 2005.
                               Alert Customer
                               Bulletin 33.
GIV-X (G450)................  Gulfstream G450       June 13, 2005.
                               Alert Customer
                               Bulletin 2.
GV-SP (G500)................  Gulfstream G500       June 13, 2005.
                               Alert Customer
                               Bulletin 3.
GV-SP (G550)................  Gulfstream G550       June 13, 2005.
                               Alert Customer
                               Bulletin 3 June 13,
                               2005.
------------------------------------------------------------------------

Airplanes Not Identified in the Gulfstream Repair Drawing

    (h) For any airplane that is found to have an Adel Wiggins floor 
heater pad system installed but that is not listed in the 
effectivity block of Gulfstream Drawing 1159SB50018: Within 25 
flight hours or 30 days after the effective date of this AD, 
whichever is first, deactivate the Adel Wiggins floor heater pad 
system in accordance with a method approved by the Manager, Atlanta 
Aircraft Certification Office (ACO), FAA.

Special Flight Permit

    (i) Special flight permits may be issued in accordance with 
sections 21.197 and 21.199 of the Federal Aviation Regulations (14 
CFR 21.197 and 21.199) to operate the airplane to a location where 
the requirements of this AD can be accomplished, provided that 
circuit breakers for the floor heater pad system are pulled and 
collared.

Alternative Methods of Compliance (AMOCs)

    (j) The Manager, Atlanta ACO, has the authority to approve AMOCs 
for this AD, if requested in accordance with the procedures found in 
14 CFR 39.19.

Material Incorporated by Reference

    (k) You must use the documents specified in Table 3 of this AD 
to perform the actions that are required by this AD, unless the AD 
specifies otherwise. The Director of the Federal Register approves 
the incorporation by reference of these documents in accordance with 
5 U.S.C. 552(a) and 1 CFR part 51. To get copies of the service 
information, contact Gulfstream Aerospace Corporation, Technical 
Publications Dept., P.O. Box 2206, Savannah, Georgia 31402-2206. To 
view the AD docket, go to the Docket Management Facility, U.S. 
Department of Transportation, 400 Seventh Street SW., room PL-401, 
Nassif Building, Washington, DC. To review copies of the service 
information, go to the National Archives and Records Administration 
(NARA). For information on the availability of this material at the 
NARA, call (202) 741-6030, or go to http://www.archives.gov/federal-register/cfr/ibr-locations.html.

              Table 3.--Material Incorporated by Reference
------------------------------------------------------------------------
  Alert customer  bulletin, including
     Gulfstream drawing 1159SB50018                    Date
------------------------------------------------------------------------
Gulfstream G-IV Alert Customer Bulletin  June 13, 2005.
 33.
Gulfstream GV Alert Customer Bulletin    June 13, 2005.
 22.
Gulfstream G300 Alert Customer Bulletin  June 13, 2005.
 33.
Gulfstream G350 Alert Customer Bulletin  June 13, 2005.
 2.

[[Page 47725]]

 
Gulfstream G400 Alert Customer Bulletin  June 13, 2005.
 33.
Gulfstream G450 Alert Customer Bulletin  June 13, 2005.
 2.
Gulfstream G500 Alert Customer Bulletin  June 13, 2005.
 3.
Gulfstream G550 Alert Customer Bulletin  June 13, 2005.
 3.
------------------------------------------------------------------------


    Issued in Renton, Washington, on August 4, 2005.
Kevin M. Mullin,
Acting Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 05-16003 Filed 8-12-05; 8:45 am]
BILLING CODE 4910-13-P

The complete text was extracted from the official GovInfo HTML edition for this publication. Acquired 2026-10-09T03:53:05.280493+00:00. Text extraction preserves the recorded source wording; it does not determine current requirements.

Open the captured official edition

Source SHA-256

54acb7aba8d3db529b595940dbf5f9b5b02d3671eadbd632cb1eeaa8cfdc8096

Text SHA-256

1941eda7117f75891573b42580a06cd1a084d152f417a085ddd257362dc985cd