Airworthiness Directives; Hamburger Flugzeugbau GmbH Model HFB 320 HANSA Airplanes

[Federal Register Volume 71, Number 26 (Wednesday, February 8, 2006)]
[Rules and Regulations]
[Pages 6342-6343]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 06-1147]


=======================================================================
-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2005-22401; Directorate Identifier 2004-NM-93-AD; 
Amendment 39-14480; AD 2006-03-16]
RIN 2120-AA64


Airworthiness Directives; Hamburger Flugzeugbau GmbH Model HFB 
320 HANSA Airplanes

AGENCY: Federal Aviation Administration (FAA), Department of 
Transportation (DOT).

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: The FAA is adopting a new airworthiness directive (AD) for all 
Hamburger Flugzeugbau GmbH Model HFB 320 HANSA airplanes. This AD 
requires revising the Limitations section of the HFB 320 Hansa Airplane 
Flight Manual to prohibit operation of the airplane past its designed 
life limit for the primary structure, which is 15,000 flight hours or 
15,000 fight cycles, whichever occurs first; and to require contacting 
the FAA for approval of analysis that the airplane is safe to continue 
operation beyond the designed life limit. This AD results from a report 
that all airplanes in operation might have met or exceeded the designed 
life limit for the primary structure. We are issuing this AD to prevent 
continued operation of an airplane beyond its designed life limit for 
the primary structure, which could result in reduced structural 
integrity of the airplane.

DATES: This AD becomes effective March 15, 2006.

ADDRESSES: You may examine the AD docket on the Internet at http://dms.dot.gov or in person at the Docket Management Facility, U.S. 
Department of Transportation, 400 Seventh Street, SW., Nassif Building, 
room PL-401, Washington, DC.

FOR FURTHER INFORMATION CONTACT: Dan Rodina, Aerospace Engineer, 
International Branch, ANM-116, Transport Airplane Directorate, FAA, 
1601 Lind Avenue, SW., Renton, Washington 98055-4056; telephone (425) 
227-2125; fax (425) 227-1149.

SUPPLEMENTARY INFORMATION:

Examining the Docket

    You may examine the airworthiness directive (AD) docket on the 
Internet at http://dms.dot.gov or in person at the Docket Management 
Facility office between 9 a.m. and 5 p.m., Monday through Friday, 
except Federal holidays. The Docket Management Facility office 
(telephone (800) 647-5227) is located on the plaza level of the Nassif 
Building at the street address stated in the ADDRESSES section.

Discussion

    The FAA issued a notice of proposed rulemaking (NPRM) to amend 14 
CFR part 39 to include an AD that would apply to all Hamburger 
Flugzeugbau GmbH Model HFB 320 HANSA airplanes. That NPRM was published 
in the Federal Register on September 14, 2005 (70 FR 54314). That NPRM 
proposed to require revising the Limitations section of the HFB 320 
Hansa Airplane Flight Manual (AFM) to prohibit operation of the 
airplane past its designed life limit for the primary structure, which 
is 15,000 flight hours or 15,000 fight cycles, whichever occurs first; 
and to require contacting the FAA for approval of analysis that the 
airplane is safe to continue operation beyond the designed life limit.

Comments

    We provided the public the opportunity to participate in the 
development of this AD. We received no comments on the NPRM or on the 
determination of the cost to the public.

Clarification of Alternative Method of Compliance (AMOC) Paragraph

    We have revised this action to clarify the appropriate procedure 
for notifying the principal inspector before using any approved AMOC on 
any airplane to which the AMOC applies.

Conclusion

    We have carefully reviewed the available data and determined that 
air safety and the public interest require adopting the AD with the 
change described previously. We have determined that this change will 
neither increase the economic burden on any operator nor increase the 
scope of the AD.

Costs of Compliance

    There are 4 airplanes of U.S. registry that will be affected by 
this AD. The revision to the Limitations section will take about 1 work 
hour per airplane at an average labor rate of $65 per work hour. Based 
on these figures, the cost of the AFM revision for U.S. operators will 
be $260, or $65 per airplane. We recognize that this AD may impose 
certain additional operational costs. However, we cannot calculate 
those costs because we cannot predict the extent of any necessary 
repairs to ensure the continued airworthiness of the affected 
airplanes.

[[Page 6343]]

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, section 106, describes the 
authority of the FAA Administrator. Subtitle VII, Aviation Programs, 
describes in more detail the scope of the Agency's authority.
    We are issuing this rulemaking under the authority described in 
subtitle VII, part A, subpart III, section 44701, ``General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    We have determined that this AD will not have federalism 
implications under Executive Order 13132. This AD will not have a 
substantial direct effect on the States, on the relationship between 
the national government and the States, or on the distribution of power 
and responsibilities among the various levels of government.
    For the reasons discussed above, I certify that this AD:
    (1) Is not a ``significant regulatory action'' under Executive 
Order 12866;
    (2) Is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and
    (3) Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.
    We prepared a regulatory evaluation of the estimated costs to 
comply with this AD and placed it in the AD docket. See the ADDRESSES 
section for a location to examine the regulatory evaluation.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Safety.

Adoption of the Amendment

0
Accordingly, under the authority delegated to me by the Administrator, 
the FAA amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The Federal Aviation Administration (FAA) amends Sec.  39.13 by 
adding the following new airworthiness directive (AD):

2006-03-16 Hamburger Flugzeugbau GmbH: Amendment 39-14480. Docket 
No. FAA-2005-22401; Directorate Identifier 2004-NM-93-AD.

Effective Date

    (a) This AD becomes effective March 15, 2006.

Affected ADs

    (b) None.

Applicability

    (c) This AD applies to all Hamburger Flugzeugbau GmbH Model HFB 
320 HANSA airplanes, certificated in any category.

Unsafe Condition

    (d) This AD results from a report that all airplanes in 
operation might have met or exceeded the designed life limit for the 
primary structure. We are issuing this AD to prevent continued 
operation of an airplane beyond its designed life limit for the 
primary structure, which could result in reduced structural 
integrity of the airplane.

Compliance

    (e) You are responsible for having the actions required by this 
AD performed within the compliance times specified, unless the 
actions have already been done.

Airworthiness Limitations Revision

    (f) Within 30 days after the effective date of this AD: Revise 
the Limitations section of the HFB 320 Hansa Airplane Flight Manual 
(AFM) to state the following (or insert a copy of this AD into the 
Limitations section):

``Do not operate the airplane beyond 15,000 total flight cycles, or 
15,000 total flight hours, whichever occurs first.''

    (g) This limitation may be removed from the HFB 320 Hansa AFM 
after the Manager, International Branch, ANM-116, FAA, approves 
analysis that would substantiate continued safe operation beyond the 
designed life limit of 15,000 total flight cycles, or within 15,000 
total flight hours on the airplane, whichever occurs first.

Alternative Methods of Compliance (AMOCs)

    (h)(1) The Manager, International Branch, ANM-116, has the 
authority to approve AMOCs for this AD, if requested in accordance 
with the procedures found in 14 CFR 39.19.
    (2) Before using any AMOC approved in accordance with Sec.  
39.19 on any airplane to which the AMOC applies, notify the 
appropriate principal inspector in the FAA Flight Standards 
Certificate Holding District Office.

Related Information

    (i) German airworthiness directive 2002-158, effective October 
3, 2002, also addresses the subject of this AD.

Material Incorporated by Reference

    (j) None.

    Issued in Renton, Washington, on January 31, 2006.
Ali Bahrami,
Manager, Transport Airplane Directorate, Aircraft Certification 
Service.
[FR Doc. 06-1147 Filed 2-7-06; 8:45 am]
BILLING CODE 4910-13-P

The complete text was extracted from the official GovInfo HTML edition for this publication. Acquired 2026-10-09T03:48:47.412844+00:00. Text extraction preserves the recorded source wording; it does not determine current requirements.

Open the captured official edition

Source SHA-256

976ef8c9eafc0120278d511f6158909852467478e59e25c948671fb28fb17df1

Text SHA-256

4131e0338f261c8759e2ee5ab933213ba3196059fa8f62a2bd8ec7309f58228f