Airworthiness Directives; General Electric Company (GE) CF34-10E Series Turbofan Engines

[Federal Register Volume 72, Number 114 (Thursday, June 14, 2007)]
[Rules and Regulations]
[Pages 32775-32776]
From the Federal Register Online via the Government Publishing Office [www.gpo.gov]
[FR Doc No: 07-2843]



[[Page 32775]]

-----------------------------------------------------------------------

DEPARTMENT OF TRANSPORTATION

Federal Aviation Administration

14 CFR Part 39

[Docket No. FAA-2006-25896; Directorate Identifier 2006-NE-33-AD; 
Amendment 39-15093; AD 2007-12-15]
RIN 2120-AA64


Airworthiness Directives; General Electric Company (GE) CF34-10E 
Series Turbofan Engines

AGENCY: Federal Aviation Administration (FAA), Department of 
Transportation (DOT).

ACTION: Final rule.

-----------------------------------------------------------------------

SUMMARY: The FAA is superseding an existing airworthiness directive 
(AD) for GE CF34-10E series turbofan engines. That AD currently 
requires removing the fuel inlet strainer from main fuel pump (MFP) 
part number (P/N) 2043M12P03, installing a certain replacement flange 
as an interim repair, remarking the MFP to P/N 2043M12P04, and 
performing initial and repetitive visual inspections of the main fuel 
filter. This AD requires removing MFPs, P/Ns 2043M12P03, 2043M12P04, 
837600-3, and 837600-4, from service and installing an improved MFP 
with a different P/N. This AD results from GE determining that the 
cause of MFP fuel strainer failure is a design problem with the 
strainer. We are issuing this AD to prevent engine in-flight shutdown 
due to MFP malfunctions.

DATES: This AD becomes effective July 19, 2007.

ADDRESSES: You can get the service information identified in this AD 
from General Electric Company via Lockheed Martin Technology Services, 
10525 Chester Road, Suite C, Cincinnati, Ohio 45215, telephone (513) 
672-8400, fax (513) 672-8422.
    You may examine the AD docket on the Internet at http://dms.dot.gov 
or in Room W12-140 on the ground floor of the West Building, 1200 New 
Jersey Avenue SE., Washington, DC 20590.

FOR FURTHER INFORMATION CONTACT: Kenneth Steeves, Aerospace Engineer, 
Engine Certification Office, FAA, Engine and Propeller Directorate, 12 
New England Executive Park, Burlington, MA 01803; telephone: (781) 238-
7765, fax: (781) 238-7199.

SUPPLEMENTARY INFORMATION: The FAA proposed to amend 14 CFR part 39 by 
superseding AD 2006-20-06, Amendment 39-14775 (71 FR 57403, September 
29, 2006), with a proposed AD. The proposed AD applies to GE CF34-
10E2A1, -10E5, -10E5A1, -10E6, -10E6A1, and -10E7 turbofan engines, 
with MFP P/Ns 2043M12P03, P/N 2043M12P04, 837600-3, and 837600-4, 
installed. We published the proposed AD in the Federal Register on 
September 29, 2006 (71 FR 57403). That action proposed to require 
removing MFPs, P/N 2043M12P03, 2043M12P04, 83600-3, and 83600-4 from 
service and installing an improved MFP, not later than July 31, 2007.

Examining the AD Docket

    You may examine the docket that contains the AD, any comments 
received, and any final disposition in person at the Docket Management 
Facility between 9 a.m. and 5 p.m., Monday through Friday, except 
Federal holidays. The Docket Office (telephone (800) 647-5227) is 
located on the plaza level of the Department of Transportation Nassif 
Building at the street address stated in ADDRESSES. Comments will be 
available in the AD docket shortly after the DMS receives them.

Comments

    We provided the public the opportunity to participate in the 
development of this AD. We have considered the comments received.

Address the Use of Parts Manufacturer Approval (PMA) Parts

    One commenter, Mr. Jack Buster of the Modification and Repair Parts 
Association (MARPA), states that the PMA part may often share the 
identical design data with the original part while carrying a 
completely different part number; therefore, it is possible the AD will 
not address certain defective PMA parts installed on the aircraft, 
allowing the unsafe condition to continue.
    The same commenter also states that it is possible that a ``new and 
improved'' PMA version of the defective original part may already exist 
in the marketplace. Therefore, specifying one approved part in 
preference to a different, but also approved part, will impart a 
commercial advantage to one manufacturer over the other.
    We agree. We changed the final rule to add the PMA P/Ns 837600-3 
and 837600-4 to the Applicability and replacement requirements of the 
final rule.

Conclusion

    We have carefully reviewed the available data, including the 
comment received, and determined that air safety and the public 
interest require adopting the AD with the changes described previously. 
We have determined that these changes will neither increase the 
economic burden on any operator nor increase the scope of the AD.

Costs of Compliance

    We estimate that this AD will affect 50 CF34-10E series turbofan 
engines installed on airplanes of U.S. registry. We also estimate that 
it will take about 3 work-hours per engine to perform the required 
actions, and that the average labor rate is $80 per work-hour. Required 
parts will cost about $4,226 per engine to upgrade the MFP to a 
different P/N to make it serviceable. Based on these figures, we 
estimate the total upgrade cost of this AD to U.S. operators to be 
$223,300.

Authority for This Rulemaking

    Title 49 of the United States Code specifies the FAA's authority to 
issue rules on aviation safety. Subtitle I, section 106, describes the 
authority of the FAA Administrator. Subtitle VII, Aviation Programs, 
describes in more detail the scope of the Agency's authority.
    We are issuing this rulemaking under the authority described in 
subtitle VII, part A, subpart III, section 44701, ``General 
requirements.'' Under that section, Congress charges the FAA with 
promoting safe flight of civil aircraft in air commerce by prescribing 
regulations for practices, methods, and procedures the Administrator 
finds necessary for safety in air commerce. This regulation is within 
the scope of that authority because it addresses an unsafe condition 
that is likely to exist or develop on products identified in this 
rulemaking action.

Regulatory Findings

    We have determined that this AD will not have federalism 
implications under Executive Order 13132. This AD will not have a 
substantial direct effect on the States, on the relationship between 
the national government and the States, or on the distribution of power 
and responsibilities among the various levels of government.
    For the reasons discussed above, I certify that this AD:
    (1) Is not a ``significant regulatory action'' under Executive 
Order 12866;
    (2) Is not a ``significant rule'' under DOT Regulatory Policies and 
Procedures (44 FR 11034, February 26, 1979); and
    (3) Will not have a significant economic impact, positive or 
negative, on a substantial number of small entities under the criteria 
of the Regulatory Flexibility Act.
    We prepared a summary of the costs to comply with this AD and 
placed it in the AD Docket. You may get a copy of

[[Page 32776]]

this summary at the address listed under ADDRESSES.

List of Subjects in 14 CFR Part 39

    Air transportation, Aircraft, Aviation safety, Safety.

Adoption of the Amendment

0
Accordingly, under the authority delegated to me by the Administrator, 
the Federal Aviation Administration amends 14 CFR part 39 as follows:

PART 39--AIRWORTHINESS DIRECTIVES

0
1. The authority citation for part 39 continues to read as follows:

    Authority: 49 U.S.C. 106(g), 40113, 44701.


Sec.  39.13  [Amended]

0
2. The FAA amends Sec.  39.13 by removing Amendment 39-14775 (71 FR 
57403, September 29, 2006) and by adding a new airworthiness directive, 
Amendment 39-15093, to read as follows:

2007-12-15 General Electric Company: Amendment 39-15093. Docket No. 
FAA-2005-25896; Directorate Identifier 2006-NE-33-AD.

Effective Date

    (a) This airworthiness directive (AD) becomes effective July 19, 
2007.

Affected ADs

    (b) This AD supersedes AD 2006-20-06, Amendment 39-14755.

Applicability

    (c) This AD applies to General Electric Company (GE) CF34-
10E2A1, -10E5, -10E5A1, -10E6, -10E6A1, and -10E7 turbofan engines, 
with main fuel pump (MFP) part number (P/N) 2043M12P03, P/N 
2043M12P04, P/N 837600-3, and P/N 837600-4 installed. These engines 
are installed on, but not limited to, Embraer ERJ 190-100-STD, ERJ 
190-100-LR, and ERJ 190-100-IGW airplanes.

Unsafe Condition

    (d) This AD results from GE determining that the cause of MFP 
fuel strainer failure is a design problem with the strainer. We are 
issuing this AD to prevent engine in-flight shutdown due to MFP 
malfunctions.

Compliance

    (e) You are responsible for having the actions required by this 
AD performed within the compliance times specified unless the 
actions have already been done.

MFP Removal and Installation

    (f) Not later than July 31, 2007, remove MFPs, P/Ns 2043M12P03, 
2043M12P04, 837600-3, and 837600-4 from service and install a 
serviceable MFP.

Definition

    (g) For the purpose of this AD, a serviceable MFP is one that 
does not have P/N 2043M12P03, 2043M12P04, 837600-3 or 837600-4.

Recommended Actions

    (h) We recommend that operators avoid performing the actions in 
this AD on both engines installed on the same airplane at the same 
time, if at all possible.

Alternative Methods of Compliance

    (i) The Manager, Engine Certification Office, FAA, has the 
authority to approve alternative methods of compliance for this AD 
if requested using the procedures found in 14 CFR 39.19.

Related Information

    (j) GE Service Bulletin No. CF34-10E S/B 73-0013, dated December 
15, 2006, pertains to the subject of this AD.
    (k) Contact Kenneth Steeves, Aerospace Engineer, Engine 
Certification Office, FAA, Engine and Propeller Directorate, 12 New 
England Executive Park, Burlington, MA 01803; telephone (781) 238-
7765, fax (781) 238-7199, for more information about this AD.

    Issued in Burlington, Massachusetts, on June 1, 2007.
Peter A. White,
Acting Manager, Engine and Propeller Directorate, Aircraft 
Certification Service.
[FR Doc. 07-2843 Filed 6-13-07; 8:45 am]
BILLING CODE 4910-13-P

The complete text was extracted from the official GovInfo HTML edition for this publication. Acquired 2026-10-09T03:37:56.502721+00:00. Text extraction preserves the recorded source wording; it does not determine current requirements.

Open the captured official edition

Source SHA-256

1408577362a94ac7ddac39c8b6afc32698903a8c8fa10037937d857996b4dd43

Text SHA-256

307c5c89ec2b10e074fd9de08080cbc4930b1b2b71497337b2ccc74bc3b190b7