AD 2020-15-08

(a) Effective Date

    This AD is effective August 31, 2020.

(b) Affected ADs

    None.

(c) Applicability

    This AD applies to all Rolls-Royce Deutschland Ltd & Co KG (Type 
Certificate previously held by Rolls-Royce plc) Trent 1000-A, Trent 
1000-A2, Trent 1000-AE, Trent 1000-AE2, Trent 1000-C, Trent 1000-C2, 
Trent 1000-CE, Trent 1000-CE2, Trent 1000-D, Trent 1000-D2, Trent 
1000-E, Trent 1000-E2, Trent 1000-G, Trent 1000-G2, Trent 1000-H, 
Trent 1000-H2, Trent 1000-J2, Trent 1000-K2, and Trent 1000-L2 model 
turbofan engines.

(d) Subject

    Joint Aircraft System Component (JASC) Code 7230, Turbine Engine 
Compressor Section.

(e) Unsafe Condition

    This AD was prompted by the manufacturer identifying 38 low-
pressure compressor (LPC) front cases, part number (P/N) KH26266 
with individual serial numbers (S/Ns), that have non-optimal 
properties that could inhibit their ability to contain certain 
engine failures. The FAA is issuing this AD to prevent failure of 
the LPC front case when subjected to high-energy debris release. The 
unsafe condition, if not addressed, could result in uncontained 
release of high-energy debris, damage to the engine, and damage to 
the airplane.

(f) Compliance

    Comply with this AD within the compliance times specified, 
unless already done.

(g) Required Actions

    After the effective date of this AD, no later than the required 
removal date specified in Appendix 1 of Rolls-Royce Alert Non-
Modification Service Bulletin (NMSB) Trent 1000 72-AK294, dated July 
16, 2019 (``Rolls-Royce Alert NMSB Trent 1000 72-AK294''):
    (1) Remove LPC front case, P/N KH26266 and with a S/N identified 
in Appendix 1 of Rolls-Royce Alert NMSB Trent 1000 72-AK294, and
    (2) Replace the LPC front case with a part eligible for 
installation.

(h) Alternative Methods of Compliance (AMOCs)

    (1) The Manager, ECO Branch, FAA, has the authority to approve 
AMOCs for this AD, if requested using the procedures found in 14 CFR 
39.19. In accordance with 14 CFR 39.19, send your request to your 
principal inspector or local Flight Standards District Office, as 
appropriate. If sending information directly to the manager of the 
ECO Branch, send it to the attention of the person identified in 
paragraph (i)(1) of this AD. You may email your request to: [email protected].
    (2) Before using any approved AMOC, notify your appropriate 
principal inspector, or lacking a principal inspector, the manager 
of the local flight standards district office/certificate holding 
district office.

(i) Related Information

    (1) For more information about this AD, contact Stephen Elwin, 
Aerospace Engineer, ECO Branch, FAA, 1200 District Avenue, 
Burlington, MA 01803; phone: 781-238-7236; fax: 781-238-7199; email: 
[email protected].
    (2) Refer to European Union Aviation Safety Agency (EASA) AD 
2019-0286, dated November 26, 2019, for more information. You may 
examine the EASA AD in the AD docket on the internet at https://www.regulations.gov by searching for and locating Docket No. FAA-
2020-0424.

(j) Material Incorporated by Reference

    (1) The Director of the Federal Register approved the 
incorporation by reference (IBR) of the service information listed 
in this paragraph under 5 U.S.C. 552(a) and 1 CFR part 51.
    (2) You must use this service information as applicable to do 
the actions required by this AD, unless the AD specifies otherwise.
    (i) Rolls-Royce plc (RR) Alert Non-Modification Service Bulletin 
Trent 1000 72-AK294, dated July 16, 2019.
    (ii) [Reserved]
    (3) For RR service information identified in this AD, contact 
Rolls-Royce Deutschland Ltd & Co KG, Eschenweg 11, 15827 
Blankenfelde-Mahlow, Germany; phone: +49 (0) 33 708 6 0; email: 
https://www.rolls-royce.com/contact-us.aspx.
    (4) You may view this service information at FAA, Airworthiness 
Products Section, Operational Safety Branch, 1200 District Avenue, 
Burlington, MA 01803. For information on the availability of this 
material at the FAA, call 781-238-7759.

[[Page 45081]]

    (5) You may view this service information that is incorporated 
by reference at the National Archives and Records Administration 
(NARA). For information on the availability of this material at 
NARA, email: [email protected], or go to: https://www.archives.gov/federal-register/cfr/ibr-locations.html.